Product name: solution 975 white lithium grease hmis codes: h f r p

M A T E R I A L S A F E T Y D A T A S H E E T VIA-0007-003 Page: 1 PRODUCT NAME: SOLUTION 975 WHITE LITHIUM GREASE HMIS CODES: H F R P PRODUCT CODE: VIA-0007-003 1 4 0 ================== SECTION I - DISTRIBUTOR IDENTIFICATION ================== DISTRIBUTOR'S NAME : MRO SOLUTIONS ADDRESS : 5645 W. HOWARD NILES, IL 60714 EMERGENCY PHONE : 1-800-424-9300 DATE PREPARED : 04/17/00 INFORMATION PHONE : 1-847-588-2480 NAME OF PREPARER : ESP ========== SECTION II - HAZARDOUS INGREDIENTS/SARA III INFORMATION ========= VAPOR PRESSURE WEIGHT REPORTABLE COMPONENTS CAS NUMBER mm Hg @ TEMP PERCENT -------------------------------------------------------------------------------- HEPTANE 142-82-5 40 72 35 OSHA PEL: 400 PPM, ACGIH TLV: 400 PPM PROPANE 74-98-6 6350 68 12 OSHA PEL: 1000 PPM, ACGIH TLV: ASPHYXIANT *** No toxic chemical(s) subject to the reporting requirements of section 313 of Title III and of 40 CFR 372 are present. *** =============== SECTION III - PHYSICAL/CHEMICAL CHARACTERISTICS ============ BOILING RANGE: -44 deg F - 208 deg F SPECIFIC GRAVITY (H2O=1): 0.76 VAPOR DENSITY: HEAVIER THAN AIR EVAPORATION RATE: SLOWER THAN ETHER SOLUBILITY IN WATER: NIL APPEARANCE AND ODOR: AEROSOL PRODUCT ================= SECTION IV - FIRE AND EXPLOSION HAZARD DATA ============== FLASH POINT: -156 deg F METHOD USED: ESTIMATED FLAMMABLE LIMITS IN AIR BY VOLUME- LOWER: 1.2 UPPER: 9.5 EXTINGUISHING MEDIA: FOAM, CO2, DRY CHEMICAL, WATER FOG SPECIAL FIREFIGHTING PROCEDURES WATER SPRAY MAY BE INEFFECTIVE. WATER MAY BE USED TO COOL CONTAINERS TO PREVENT PRESSURE BUILD-UP AND EXPLOSION WHEN EXPOSED TO EXTREME HEAT. IF WATER IS USED, FOG NOZZLES PREFERRED. WEAR GOGGLES AND SELF-CONTAINED BREATHING APPARATUS. UNUSUAL FIRE AND EXPLOSION HAZARDS CLOSED CONTAINERS MAY EXPLODE FROM INTERNAL PRESSURE BUILD-UP WHEN EXPOSED TO EXTREME HEAT AND DISCHARGE CONTENTS. VAPOR ACCUMULATION CAN FLASH OR EXPLODE IF IGNITED. OVEREXPOSURE TO DECOMPOSITION PRODUCTS MAY CAUSE A HEALTH HAZARD. SYMPTOMS MAY NOT BE READILY APPARENT. OBTAIN MEDICAL ATTENTION. ======================== SECTION V - REACTIVITY DATA ======================= STABILITY: STABLE CONDITIONS TO AVOID APPLICATION TO HOT SURFACES. STORAGE ABOVE 120 DEG F. EXPOSURE TO OPEN FLAME. INCOMPATIBILITY (MATERIALS TO AVOID) STRONG OXIDIZING AGENTS. HAZARDOUS DECOMPOSITION OR BYPRODUCTS M A T E R I A L S A F E T Y D A T A S H E E T VIA-0007-003 Page: 2 MAY PRODUCE FUMES WHEN HEATED TO DECOMPOSITION. FUMES MAY CONTAIN CARBON MONOXIDE. HAZARDOUS POLYMERIZATION: WILL NOT OCCUR ==================== SECTION VI - HEALTH HAZARD DATA ======================= INHALATION HEALTH RISKS AND SYMPTOMS OF EXPOSURE RESPIRATORY IRRITATION, HEADACHE, NAUSEA, FATIGUE, DROWSINESS, IMPAIRED CO- ORDINATION. SKIN AND EYE CONTACT HEALTH RISKS AND SYMPTOMS OF EXPOSURE SKIN: CONTACT MAY DRY THE SKIN; PROLONGED CONTACT MAY CAUSE MODERATE IRRITATION. EYES: LIQUID OR VAPOR CAN CAUSE MODERATE TO SEVERE IRRITATION. SKIN ABSORPTION HEALTH RISKS AND SYMPTOMS OF EXPOSURE NOT EASILY ABSORBED. SOLVENT ACTION CAN DRY AND DEFAT THE SKIN CAUSING THE SKIN TO CRACK, LEADING TO DERMATITIS. INGESTION HEALTH RISKS AND SYMPTOMS OF EXPOSURE NOT A LIKELY ROUTE OF EXPOSURE. IF SWALLOWED, DO NOT INDUCE VOMITING. SEEK IMMEDIATE MEDICAL ADVICE AND/OR ATTENTION. HEALTH HAZARDS (ACUTE AND CHRONIC) ACUTE: EYE IRRITANT. POSSIBLE SKIN IRRITANT. CHRONIC: NONE KNOWN. CARCINOGENICITY: NTP CARCINOGEN: No IARC MONOGRAPHS: No OSHA REGULATED: No MEDICAL CONDITIONS GENERALLY AGGRAVATED BY EXPOSURE NONE KNOWN. EMERGENCY AND FIRST AID PROCEDURES INHALATION: REMOVE TO FRESH AIR. ADMINISTER OXYGEN IF NEEDED. APPLY ARTIFICIAL RESPIRATION IF BREATHING HAS STOPPED. GET MEDICAL ATTENTION. SKIN: WIPE OFF WITH TOWEL. WASH WITH SOAP AND WATER. GET MEDICAL ATTENTION IF IRRITATION PERSISTS. EYES: WASH IMMEDIATELY WITH LARGE VOLUMES OF FRESH WATER FOR AT LEAST 15 MINUTES. GET MEDICAL ATTENTION. =========== SECTION VII - PRECAUTIONS FOR SAFE HANDLING AND USE ============ STEPS TO BE TAKEN IN CASE MATERIAL IS RELEASED OR SPILLED AVOID BREATHING VAPORS. VENTILATE AREA. REMOVE ALL SOURCES OF IGNITION. CLEAN UP AREA WITH ABSORBENT MATERIAL AND PLACE IN CLOSED CONTAINERS FOR DISPOSAL. WASTE DISPOSAL METHOD DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE, AND FEDERAL REGULATIONS. BEFORE ATTEMPTING CLEAN UP, REFER TO OTHER SECTIONS OF THIS MSDS FOR HAZARD CAUTION INFORMATION. PRECAUTIONS TO BE TAKEN IN HANDLING AND STORING STORE AND USE IN COOL, DRY, WELL-VENTILATED AREAS. DO NOT STORE ABOVE 120 DEG F. DO NOT PUNCTURE OR INCINERATE (BURN) CANS. DO NOT STICK PIN, NAIL OR ANY OTHER SHARP OBJECT INTO OPENING ON TOP OF CAN. DO NOT SPRAY IN EYES. DO NOT TAKE INTERNALLY. SEE PRODUCT LABEL FOR ADDITIONAL INFORMATION. OTHER PRECAUTIONS SMALL PRESSURIZED CONTAINERS OF FLAMMABLE PRODUCTS MAY BE STORED IN AREAS SUITABLE FOR ORDINARY COMBUSTIBLES WITH RESPECT TO CONSTRUCTION, DRAINAGE, CONTROL OF IGNITION SOURCES, AND VENTILATION EXCEPT THAT THEY SHOULD NOT BE M A T E R I A L S A F E T Y D A T A S H E E T VIA-0007-003 Page: 3 STORED IN BASEMENTS. ===================== SECTION VIII - CONTROL MEASURES ====================== RESPIRATORY PROTECTION NONE UNDER NORMAL USE. AVOID BREATHING VAPORS. IN RESTRICTED AREAS, USE APPROVED CHEMICAL/MECHANICAL FILTERS DESIGNED TO REMOVE A COMBINATION OF PARTICLES AND VAPOR. IN CONFINED AREAS, USE APPROVED AIR LINE TYPE RESPIRATOR OR HOOD. SELF- CONTAINED BREATHING APPARATUS IS REQUIRED FOR VAPOR CONCENTRATIONS ABOVE PEL/TLV LIMITS. VENTILATION SUFFICIENT TO PREVENT INHALATION OF SOLVENT VAPORS. GENERAL DILUTION AND/OR LOCAL EXHAUST VENTILATION IN VOLUME OR PATTERN TO KEEP PEL/TLV OF MOST HAZARDOUS INGREDIENT BELOW ACCEPTABLE LIMIT AND LEL BELOW STATED LIMIT. PROTECTIVE GLOVES NONE UNDER NORMAL USE. SOLVENT RESISTANT REQUIRED FOR PROLONGED OR REPEATED CONTACT. EYE PROTECTION NONE UNDER NORMAL USE; HOWEVER, USE OF SAFETY GLASSES WITH SPLASH GUARDS OR FULL FACE SHIELD IS RECOMMENDED. OTHER PROTECTIVE CLOTHING OR EQUIPMENT NONE UNDER NORMAL USE; HOWEVER, USE OF SOLVENT RESISTANT APRONS OR OTHER CLOTHING IS RECOMMENDED. WORK/HYGIENIC PRACTICES EYE WASHES AND SAFETY SHOWERS IN THE WORKPLACE ARE RECOMMENDED. ========================= SECTION IX - DISCLAIMER ========================== THE INFORMATION CONTAINED HEREIN IS BASED ON DATA CONSIDERED ACCURATE. HOWEVER, NO WARRANTY IS EXPRESSED OR IMPLIED REGARDING THE ACCURACY OF THE DATA OR THE RESULTS TO BE OBTAINED FROM THE USE THEREOF. BECAUSE THE INFORMATION CONTAINED HEREIN MAY BE APPLIED UNDER CONDITIONS BEYOND OUR CONTROL, WE ASSUME NO RESPONSIBILITY FOR ITS USE.

Source: http://www.mrosolutions.net/msds/975g.pdf